Experimental Investigation of the Effect of Using Safflower Methyl Ester-Jet A1 Blends on Engine Performance and Emissions in Mini Jet Engine

Mustafa Taşyürek; Soner Şen

Makale detayları

Experimental Investigation of the Effect of Using Safflower Methyl Ester-Jet A1 Blends on Engine Performance and Emissions in Mini Jet Engine

Yazarlar:

Mustafa Taşyürek | Soner Şen

Yayıncı:

Igdir University

Ana Başlıklar:

Makine Mühendisliği (Diğer)

Dergi:

Iğdır Üniversitesi Fen Bilimleri Enstitüsü Dergisi Vol.14 Issue 1, pp.377-389

Belge Tipi:

Makale

Yayın Tarihi:

1/2024

Belge Dili:

İngilizce

Document ID (Org No.):

2001311759

pISSN:

2536-4618

Anahtar kelimeler:

Özet:

 This study focused on the investigation of the effect of the SME-Jet A1 mixture on the thrust performance, fuel consumption and pollutant emissions of a small-scale jet engine, also the alternative of safflower methyl ester SME to Jet A1 fuel. The experiments were carried out by using bio jet fuels obtained by mixing Jet A1 and the fuel produced from safflower oil in taxi, approach, climb and take-off power cycles of a jet engine. The thrust forces of both types of fuel obtained from the percentage power values of the aircraft under real operating conditions were determined and accordingly CO, HC, CO2 emissions, fuel consumption and exhaust gas temperature measurements were made. As a result of the measurements, approximately 27.5 reduction in thrust was observed with the use of biojet. In addition, HC emissions decreased by up to 51, while CO emissions increased by 30 at take off while being closer to each other at low rpm. While the CO2 emissions of methyl ester increased by 8-16 depending on the speed change, fuel consumption, while at an acceptable level at low rpm, exceeded 50 at take off.

 This study focused on the investigation of the effect of the SME-Jet A1 mixture on the thrust performance, fuel consumption and pollutant emissions of a small-scale jet engine, also the alternative of safflower methyl ester SME to Jet A1 fuel. The experiments were carried out by using bio jet fuels obtained by mixing Jet A1 and the fuel produced from safflower oil in taxi, approach, climb and take-off power cycles of a jet engine. The thrust forces of both types of fuel obtained from the percentage power values of the aircraft under real operating conditions were determined and accordingly CO, HC, CO2 emissions, fuel consumption and exhaust gas temperature measurements were made. As a result of the measurements, approximately 27.5 reduction in thrust was observed with the use of biojet. In addition, HC emissions decreased by up to 51, while CO emissions increased by 30 at take off while being closer to each other at low rpm. While the CO2 emissions of methyl ester increased by 8-16 depending on the speed change, fuel consumption, while at an acceptable level at low rpm, exceeded 50 at take off.

 This study focused on the investigation of the effect of the SME-Jet A1 mixture on the thrust performance, fuel consumption and pollutant emissions of a small-scale jet engine, also the alternative of safflower methyl ester SME to Jet A1 fuel. The experiments were carried out by using bio jet fuels obtained by mixing Jet A1 and the fuel produced from safflower oil in taxi, approach, climb and take-off power cycles of a jet engine. The thrust forces of both types of fuel obtained from the percentage power values of the aircraft under real operating conditions were determined and accordingly CO, HC, CO2 emissions, fuel consumption and exhaust gas temperature measurements were made. As a result of the measurements, approximately 27.5 reduction in thrust was observed with the use of biojet. In addition, HC emissions decreased by up to 51, while CO emissions increased by 30 at take off while being closer to each other at low rpm. While the CO2 emissions of methyl ester increased by 8-16 depending on the speed change, fuel consumption, while at an acceptable level at low rpm, exceeded 50 at take off.

 Bu çalışma, Aspir Metil Esteri-Jet A1 karışımının küçük ölçekli bir jet motorunun itme performansı, yakıt tüketimi ve kirletici emisyonları üzerindeki etkisinin ve ayrıca Jet A1 yakıtına aspir metil esterinin SME alternatifinin araştırılmasına odaklanmıştır. Deneyler, Jet A1 ile aspir yağından üretilen yakıtın karıştırılmasıyla elde edilen biyojet yakıtlarının bir jet motorunun taksi, yaklaşma, tırmanma ve kalkış güç çevrimlerinde kullanılmasıyla gerçekleştirilmiştir. Uçağın gerçek çalışma şartlarındaki yüzde güç değerlerinden elde edilen her iki yakıt tipinin itme kuvvetleri belirlenmiş ve buna göre CO, HC, CO2 emisyonları, yakıt tüketimi ve egzoz gazı sıcaklığı ölçümleri yapılmıştır. Yapılan ölçümler sonucunda biyojet kullanımıyla itkide yaklaşık 27.5 oranında azalma görülmüştür. Ayrıca HC emisyonları 51e kadar azalırken CO emisyonu düşük devirlerde birbirine daha yakınken tam güçte  30 artmıştır. Metil esterin CO2 emisyonu devir değişikliğine göre  8-16 arası artış gösterirken, yakıt tüketimi düşük devirlerde kabul edilebilir düzeyde iken tam güçte  50yi aşmıştır.

Makale detayları

Experimental Investigation of the Effect of Using Safflower Methyl Ester-Jet A1 Blends on Engine Performance and Emissions in Mini Jet Engine

Yazarlar:

Mustafa Taşyürek | Soner Şen

Yayıncı:

Igdir University

Ana Başlıklar:

Makine Mühendisliği (Diğer)

Dergi:

Iğdır Üniversitesi Fen Bilimleri Enstitüsü Dergisi Vol.14 Issue 1, pp.377-389

Belge Tipi:

Makale

Yayın Tarihi:

1/2024

Belge Dili:

İngilizce

Document ID (Org No.):

2001311759

pISSN:

2536-4618

Aviation fuels

Emission

Jet a1

Jet engine

Safflower methyl esterHavacılık yakıtları

Emisyon

Jet a1

Jet motoru

Aspir metil esteri

Sayı

Makale detayları

Yazarlar: Mustafa Taşyürek | Soner Şen

Yayıncı: Igdir University

Ana Başlıklar: Makine Mühendisliği (Diğer)

Dergi: Iğdır Üniversitesi Fen Bilimleri Enstitüsü Dergisi Vol.14 Issue 1, pp.377-389

Belge Tipi: Makale

Yayın Tarihi: 1/2024

Belge Dili: İngilizce

Document ID (Org No.): 2001311759

pISSN: 2536-4618

Sayı

Yazarlar:

Mustafa Taşyürek | Soner Şen

Yayıncı:

Igdir University

Ana Başlıklar:

Makine Mühendisliği (Diğer)

Dergi:

Iğdır Üniversitesi Fen Bilimleri Enstitüsü Dergisi Vol.14 Issue 1, pp.377-389

Belge Tipi:

Makale

Yayın Tarihi:

1/2024

Belge Dili:

İngilizce

Document ID (Org No.):

2001311759

pISSN:

2536-4618