Development and evaluation of taste masked orally disintegrating tablets of pioglitazone hydrochloride

Ashwin Kuchekar

Makale detayları

Development and evaluation of taste masked orally disintegrating tablets of pioglitazone hydrochloride

Yazarlar:

Ashwin Kuchekar

Yayıncı:

Marmara University

Ana Başlıklar:

Pharmaceutical Delivery Technologies

Dergi:

Journal of Research in Pharmacy Vol.26 Issue 6, pp.1619-1635

Belge Tipi:

Makale

Yayın Tarihi:

6/2025

Belge Dili:

İngilizce

Document ID (Org No.):

2001347772

pISSN:

2630-6344

Anahtar kelimeler:

Özet:

 Orally disintegrating tablets, over the years, have become the preferred alternative to conventional tablets and capsule dosage forms because of better compliance. These are suitable for special populations like pediatrics, geriatrics, patient with dysphagia, patients with hand tremors, patients with frequent traveling, etc. The focus of this research was to mask the unpleasant taste of type 2 antidiabetic drug Pioglitazone Hydrochloride followed by designing an orally disintegrating tablet of the same. Taste masking was accomplished using a pH-independent polymeric dispersion of ethylcellulose i.e. Surelease E-7-19040 in combination with a Hypromellose-based ready-tocoat film coating system i.e. Opadry YS-1-19025-A in a different ratio. Uncoated powder, coated granules, and prepared tablets of Pioglitazone Hydrochloride were investigated for in-vivo taste evaluation and flow as well as compression behavior, Fourier Transform Infrared spectra, scanning electron microscopy, powder X-ray diffraction, and in-vitro dissolution, disintegration properties. The study demonstrated the use of 32 full factorial design study to identify optimal ratio of pore former in Surelease and Opadry polymeric coating combination to achieve desired taste masking of unpleasant Pioglitazone Hydrochloride without any impact on immediate release characterstic of the orally disintegtrating tablet formulation. It further demonstrated that, an increase in pore former concentration resulted in a lower rating by human volunteers indicating relatively more bitterness, however, an increase in percent weight gain resulted in a higher rating by human volunteers indicating efficient taste masking.

 Orally disintegrating tablets, over the years, have become the preferred alternative to conventional tablets and capsule dosage forms because of better compliance. These are suitable for special populations like pediatrics, geriatrics, patient with dysphagia, patients with hand tremors, patients with frequent traveling, etc. The focus of this research was to mask the unpleasant taste of type 2 antidiabetic drug Pioglitazone Hydrochloride followed by designing an orally disintegrating tablet of the same. Taste masking was accomplished using a pH-independent polymeric dispersion of ethylcellulose i.e. Surelease E-7-19040 in combination with a Hypromellose-based ready-tocoat film coating system i.e. Opadry YS-1-19025-A in a different ratio. Uncoated powder, coated granules, and prepared tablets of Pioglitazone Hydrochloride were investigated for in-vivo taste evaluation and flow as well as compression behavior, Fourier Transform Infrared spectra, scanning electron microscopy, powder X-ray diffraction, and in-vitro dissolution, disintegration properties. The study demonstrated the use of 32 full factorial design study to identify optimal ratio of pore former in Surelease and Opadry polymeric coating combination to achieve desired taste masking of unpleasant Pioglitazone Hydrochloride without any impact on immediate release characterstic of the orally disintegtrating tablet formulation. It further demonstrated that, an increase in pore former concentration resulted in a lower rating by human volunteers indicating relatively more bitterness, however, an increase in percent weight gain resulted in a higher rating by human volunteers indicating efficient taste masking.

 Orally disintegrating tablets, over the years, have become the preferred alternative to conventional tablets and capsule dosage forms because of better compliance. These are suitable for special populations like pediatrics, geriatrics, patient with dysphagia, patients with hand tremors, patients with frequent traveling, etc. The focus of this research was to mask the unpleasant taste of type 2 antidiabetic drug Pioglitazone Hydrochloride followed by designing an orally disintegrating tablet of the same. Taste masking was accomplished using a pH-independent polymeric dispersion of ethylcellulose i.e. Surelease E-7-19040 in combination with a Hypromellose-based ready-tocoat film coating system i.e. Opadry YS-1-19025-A in a different ratio. Uncoated powder, coated granules, and prepared tablets of Pioglitazone Hydrochloride were investigated for in-vivo taste evaluation and flow as well as compression behavior, Fourier Transform Infrared spectra, scanning electron microscopy, powder X-ray diffraction, and in-vitro dissolution, disintegration properties. The study demonstrated the use of 32 full factorial design study to identify optimal ratio of pore former in Surelease and Opadry polymeric coating combination to achieve desired taste masking of unpleasant Pioglitazone Hydrochloride without any impact on immediate release characterstic of the orally disintegtrating tablet formulation. It further demonstrated that, an increase in pore former concentration resulted in a lower rating by human volunteers indicating relatively more bitterness, however, an increase in percent weight gain resulted in a higher rating by human volunteers indicating efficient taste masking.

 Orally disintegrating tablets, over the years, have become the preferred alternative to conventional tablets and capsule dosage forms because of better compliance. These are suitable for special populations like pediatrics, geriatrics, patient with dysphagia, patients with hand tremors, patients with frequent traveling, etc. The focus of this research was to mask the unpleasant taste of type 2 antidiabetic drug Pioglitazone Hydrochloride followed by designing an orally disintegrating tablet of the same. Taste masking was accomplished using a pH-independent polymeric dispersion of ethylcellulose i.e. Surelease E-7-19040 in combination with a Hypromellose-based ready-tocoat film coating system i.e. Opadry YS-1-19025-A in a different ratio. Uncoated powder, coated granules, and prepared tablets of Pioglitazone Hydrochloride were investigated for in-vivo taste evaluation and flow as well as compression behavior, Fourier Transform Infrared spectra, scanning electron microscopy, powder X-ray diffraction, and in-vitro dissolution, disintegration properties. The study demonstrated the use of 32 full factorial design study to identify optimal ratio of pore former in Surelease and Opadry polymeric coating combination to achieve desired taste masking of unpleasant Pioglitazone Hydrochloride without any impact on immediate release characterstic of the orally disintegtrating tablet formulation. It further demonstrated that, an increase in pore former concentration resulted in a lower rating by human volunteers indicating relatively more bitterness, however, an increase in percent weight gain resulted in a higher rating by human volunteers indicating efficient taste masking.

Makale detayları

Development and evaluation of taste masked orally disintegrating tablets of pioglitazone hydrochloride

Yazarlar:

Ashwin Kuchekar

Yayıncı:

Marmara University

Ana Başlıklar:

Pharmaceutical Delivery Technologies

Dergi:

Journal of Research in Pharmacy Vol.26 Issue 6, pp.1619-1635

Belge Tipi:

Makale

Yayın Tarihi:

6/2025

Belge Dili:

İngilizce

Document ID (Org No.):

2001347772

pISSN:

2630-6344

Taste masking

orally disintegrating tablets

coating

polymeric dispersion

direct compression

Sayı

Makale detayları

Development and evaluation of taste masked orally disintegrating tablets of pioglitazone hydrochloride

Yazarlar: Ashwin Kuchekar

Yayıncı: Marmara University

Ana Başlıklar: Pharmaceutical Delivery Technologies

Dergi: Journal of Research in Pharmacy Vol.26 Issue 6, pp.1619-1635

Belge Tipi: Makale

Yayın Tarihi: 6/2025

Belge Dili: İngilizce

Document ID (Org No.): 2001347772

pISSN: 2630-6344

Taste masking

orally disintegrating tablets

coating

polymeric dispersion

direct compression

Sayı

Yazarlar:

Ashwin Kuchekar

Yayıncı:

Marmara University

Ana Başlıklar:

Pharmaceutical Delivery Technologies

Dergi:

Journal of Research in Pharmacy Vol.26 Issue 6, pp.1619-1635

Belge Tipi:

Makale

Yayın Tarihi:

6/2025

Belge Dili:

İngilizce

Document ID (Org No.):

2001347772

pISSN:

2630-6344